Solar Panel Van Roof Mount

Solar cable glands bridge the gap between the roof and the interior of your van.

Solar panel van roof mount.

Clean roof and apply loctite pl adhesive. Two 100 watt solar panels will be mounted to the roof of your van and secured to your vehicle s roof rack. Adjustable tilt mounts can get you better efficiency on the roof or work as a stand if you are using portable panels. The solar panel roof mount was built from scratch by securing aluminum slotted hole strut channels unistrut through factory drilled holes in the roof of the ford transit.

6 pre fit solar panels on the roof to define location of cable glands. Dry fit the solar panels on the van roof. Get it as soon as tue sep 15. Mounting solar panels to the roof of a van.

Mark the location of the solar panel to avoid having the measure again afterward. These two solar panels will generate electricity harvested from the power of the sun and the energy that these two panels create will be passed through a series of adapter cables to your solar charge controller. Mark and drill holes in the van roof. One side of the angle is bolted screwed or adhered to the roof surface while the other side is attached to the panel.

Each side of the van has 8 1 2 foot runs of unistrut. Most solar panels are designed to sit on the roof of a house not to be driving down the road at 70 miles per hour. Free shipping on your first order shipped by amazon. The panels themselves can take much higher wind speeds but it s all in how you mount them to the roof.

What we used to mount our solar panels. We found it easier to work with if we install the glands at approximately 12 inches from the panels. With an adjustable tilt mount you can install solar panels with or without a z bracket. Cut plywood reinforcement strips and drill holes.

Bolt solar panels to roof and plywood strips. 7 remove solar panels and drill holes for the. The most efficient way to mount panels would be at the correct angle to point them straight at the sun. It s also good to see how your flat panels will lay on a curved roof.

The simplest method the easiest way to mount a solar panel to the roof uses a few lengths of angle aluminum. Attach brackets to the solar panels. I had the general idea of where i wanted the solar panels to sit on top of my van but without dry fitting them first i would have overlooked how the mounting holes actually lined up on the contoured roof. Powiser solar panel mounting z bracket mounts solar panel roof mounting kit with nuts and bolts for rv roof boat and other off gird roof installation 2 sets of mount brackets 4 7 out of 5 stars 18.

A 4th solar panel could fit on the roof but was not installed.